Oldtimer
Active Member
Do we have an on site listing of tsbs and tsrs for the 07 4.6?
Thanks,
Jim
Thanks,
Jim
TSBs
- Thread starter Oldtimer
- Start date
Help Support Ford SportTrac Forum:
Thomas Rogers
Well-Known Member
OT,
What problems are you having?
TJR
What problems are you having?
TJR
Steve McKellop
Well-Known Member
Field Service Actions (Recalls)
2007 EXPLORER SPORT TRAC - US (English)
The Field Service Actions (FSA's) listed here may NOT apply to the vehicle you are working on. You MUST run OASIS with a specific VIN to determine if it applies. If OASIS does not return the FSA, then it does NOT apply.
07S52
Safety Recall - Certain 2007 Explorer and Explorer Sport Trac Vehicles - Steering Gear Assembly Bolt Replacement
Published 04/19/2007
09L03
Special Field Action - Certain 2007-2008 Vehicle Lines - Tire Valve Stem Inspection and Maintenance Reminder
Published 04/24/2009
________________
Documents found: 2
Technical Service Bulletins
2007 EXPLORER SPORT TRAC - US (English)
The Technical Service Bulletins (TSB's) listed here may NOT apply to the vehicle you are working on. You MUST run OASIS with a specific VIN and Symptom Code to determine if it applies. If OASIS does not return the TSB, then it does NOT apply.
09-14-1
17 INCH BRIGHT MACHINED WHEEL - CORROSION AND ETCHING
09-12-12
5R55S/5R55N/5R55W TRANSMISSIONS - SHIFT CONCERNS, LOSS OF 2ND, 3RD AND 5TH GEAR, INCORRECT RATIO DTC'S - PROCEDURE TO INSPECT AND REPAIR SERVO PIN BORE WEAR
09-11-12
COOLANT EXPANSION TANK LEAKS - 4.0L ENGINE
09-11-2
POPPING/SNAPPING NOISE - FRONT OR REAR 18 INCH WHEELS - TURNING AT SLOW SPEED BELOW 10 MPH (16 KM/H)
09-9-7
COLD START FEAD HOOT - WHISTLE NOISE
09-8-1
4.0L COOLANT LEAK - RADIATOR - BUILT ON OR BEFORE 8/8/2006
09-7-7
4.0L ENGINE BELT SQUEAL OR CHIRP NOISE ON COLD STARTUP
09-2-9
SUN VISOR MIRROR COVER CRACKING - BUILT BETWEEN 1/2/2007 AND 11/3/2008
09-1-6
IMPROVED BRAKE PEDAL FEEL AND FIRMNESS - BUILT BEFORE 5/31/2008
09-1-2
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0456 - BUILT ON OR BEFORE 4/14/2008
08-24-4
DRIVELINE BUMP WHILE BRAKING - BELOW 10 MPH (16 KM/H)
08-24-2
VIBRATION DIAGNOSTICS - STEERING WHEEL NIBBLE - TIRE WHEEL RUNOUT AND BALANCE
08-21-11
4 WHEEL DRIVE/ALL WHEEL DRIVE - WITH CONTROL TRAC - SHUDDER ON ACCELERATION/DECELERATION OR BINDING ON SLOW TURNS
08-19-6
HIGH PITCHED SQUEAL NOISE FROM THE REAR AXLE AREA - BUILT ON OR BEFORE 7/28/2008
08-19-3
UNITIZED SEAL DIAGNOSIS - LEAK / GREASE OIL SEPARATION - AXLE BEARING SEAL 8.8 IFS, 8.8 IRS, AND 9.75 IRS AXLES
08-18-2
MIL ON - P0506 AND/OR P0505 - HESITATION/LOSS OF RPM/DIFFICULTY STARTING/LOW IDLE RPM
08-11-6
A/C COMPRESSOR THUMP NOISE
08-10-4
CHROME GRILLE - PEELING, BLISTERING OR WRINKLING
08-9-5
4.0L/4.6L - HARD START/ROUGH RUNNING - AFTER LONG HOT SOAK / DIP IN RPM WHEN COMING TO A STOP - BUILT ON OR BEFORE 4/2/2008
08-7-6
SPARK PLUG REMOVAL INSTRUCTIONS - 4.6L 3V/5.4L 3V/6.8L 3V
08-5-9
THUMPING/LOUD FLUTTER - BEHIND DASH IN DEFROST MODE - LACK OF AIRFLOW TO FLOOR - MANUAL A/C ONLY
08-1-3
4.0L - PCM BRACKET BUZZ/HUM NOISE FROM CENTER/RIGHT SIDE DASH AREA
07-25-10
LOOSE OUTSIDE SEAT CUSHION SHIELD - VEHICLES BUILT BEFORE 7/1/2007
07-25-2
TAILGATE STRIKER - NOISE/RATTLE
07-24-6
REAR BRAKE RATTLE OVER BUMPS
07-17-4
PARKING BRAKE RELEASE HANDLE BREAKS - VEHICLES BUILT BEFORE 12/1/2006
07-12-9
INTERMITTENT CONDITION - SHIFTER REQUIRES MANUAL OVERRIDE TO GET VEHICLE OUT OF PARK - VEHICLES BUILT ON OR BEFORE 11/14/2006
07-12-6
FRONT BLOWER MOTOR WHISTLE NOISE - VEHICLES BUILT ON OR BEFORE 06/7/2007
07-12-3
RCM FAULT REPORTING USING DTCS AND BIT-MAPPED PARAMETER IDENTIFIERS (PIDS) - SERVICE TIPS
07-12-2
16 INCH BRIGHT MACHINED WHEEL - CORROSION AND ETCHING
07-10-12
VARIOUS DRIVEABILITY AND A/C PERFORMANCE QUALITY SYMPTOMS - 4.6L 3V 6R60 EQUIPPED VEHICLES ONLY
07-7-3
FRONT SEAT MANUAL LUMBAR INOPERATIVE
07-6-3
6R60/75 - DTC-MECHATRONIC ASSEMBLY / POSSIBLE WRENCH LIGHT ON
07-5-13
DISCHARGED BATTERIES - VEHICLES IN STORAGE/LIMITED USAGE
07-5-8
BATTERY SERVICE - OPERATION OF BATTERY EYE - CHARGING SERVICE TIPS
07-4-3
LEATHER-WRAPPED STEERING WHEEL - LEATHER COMING LOOSE
06-25-15
ALUMINUM BODY PANELS - CORROSION - SERVICE TIP
06-25-3
PIONEER NAVIGATION RADIO - SEEK FUNCTION INOPERATIVE - SERVICE TIP
06-24-14
LOWER STEERING COLUMN SHAFT POP / CLUNK NOISE
06-21-19
HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)
06-21-16
WATER NOISE - WATER ACCUMULATION INSIDE DOORS
06-21-7
AUDIO / NAVIGATION SERVICE AND ORDERING PROCEDURES
06-19-14
NO CRANK / STARTER TERMINAL FATIGUE
06-19-12
DTC P0340/P0344/P0345/P0349 - 4.6L 3V AND 5.4L 3V
06-18-15
IGNITION DIAGNOSTICS
06-17-13
CALIBRATION UPDATE 4.0L - VARIOUS SYMPTOMS - SURGE, HESITATION, TORQUE CONVERTER CYCLING, NO UP SHIFT AFTER A FORCED DOWNSHIFT, AND POOR A/C PERFORMANCE
06-17-5
WHEEL LIP MOULDINGS - POOR FIT TO BUMPER FASCIA
06-14-8
WIND / WHISTLE NOISE AT 40-70 MPH (64-113 KM/H) - LEFT MIRROR AREA
06-12-12
A/C COMPRESSOR THUMP NOISE WITH 4.0L V-6
06-11-5
GAP OR WARPAGE AT TOP OF TAILGATE LINER
06-10-7
NO START WITH INSTRUMENT CLUSTER INOPERATIVE
06-7-10
MIL ON WITH DTC P2004 THROUGH P2008, P151A, P2015, P2020 - 4.6L 3V
06-7-1
NEUTRAL TOW CAPABILITY - SERVICE KIT REQUIREMENTS
06-6-9
ANTI-LOCK BRAKE SYSTEM / TRACTION CONTROL / ROLL STABILITY CONTROL INDICATOR (ABS / TC / RSC) WARNING LAMP ON WITH DTC C1440
________________
TSBs found:54
2007 EXPLORER SPORT TRAC - US (English)
The Field Service Actions (FSA's) listed here may NOT apply to the vehicle you are working on. You MUST run OASIS with a specific VIN to determine if it applies. If OASIS does not return the FSA, then it does NOT apply.
07S52
Safety Recall - Certain 2007 Explorer and Explorer Sport Trac Vehicles - Steering Gear Assembly Bolt Replacement
Published 04/19/2007
09L03
Special Field Action - Certain 2007-2008 Vehicle Lines - Tire Valve Stem Inspection and Maintenance Reminder
Published 04/24/2009
________________
Documents found: 2
Technical Service Bulletins
2007 EXPLORER SPORT TRAC - US (English)
The Technical Service Bulletins (TSB's) listed here may NOT apply to the vehicle you are working on. You MUST run OASIS with a specific VIN and Symptom Code to determine if it applies. If OASIS does not return the TSB, then it does NOT apply.
09-14-1
17 INCH BRIGHT MACHINED WHEEL - CORROSION AND ETCHING
09-12-12
5R55S/5R55N/5R55W TRANSMISSIONS - SHIFT CONCERNS, LOSS OF 2ND, 3RD AND 5TH GEAR, INCORRECT RATIO DTC'S - PROCEDURE TO INSPECT AND REPAIR SERVO PIN BORE WEAR
09-11-12
COOLANT EXPANSION TANK LEAKS - 4.0L ENGINE
09-11-2
POPPING/SNAPPING NOISE - FRONT OR REAR 18 INCH WHEELS - TURNING AT SLOW SPEED BELOW 10 MPH (16 KM/H)
09-9-7
COLD START FEAD HOOT - WHISTLE NOISE
09-8-1
4.0L COOLANT LEAK - RADIATOR - BUILT ON OR BEFORE 8/8/2006
09-7-7
4.0L ENGINE BELT SQUEAL OR CHIRP NOISE ON COLD STARTUP
09-2-9
SUN VISOR MIRROR COVER CRACKING - BUILT BETWEEN 1/2/2007 AND 11/3/2008
09-1-6
IMPROVED BRAKE PEDAL FEEL AND FIRMNESS - BUILT BEFORE 5/31/2008
09-1-2
MALFUNCTION INDICATOR LAMP (MIL) ON WITH DIAGNOSTIC TROUBLE CODE (DTC) P0456 - BUILT ON OR BEFORE 4/14/2008
08-24-4
DRIVELINE BUMP WHILE BRAKING - BELOW 10 MPH (16 KM/H)
08-24-2
VIBRATION DIAGNOSTICS - STEERING WHEEL NIBBLE - TIRE WHEEL RUNOUT AND BALANCE
08-21-11
4 WHEEL DRIVE/ALL WHEEL DRIVE - WITH CONTROL TRAC - SHUDDER ON ACCELERATION/DECELERATION OR BINDING ON SLOW TURNS
08-19-6
HIGH PITCHED SQUEAL NOISE FROM THE REAR AXLE AREA - BUILT ON OR BEFORE 7/28/2008
08-19-3
UNITIZED SEAL DIAGNOSIS - LEAK / GREASE OIL SEPARATION - AXLE BEARING SEAL 8.8 IFS, 8.8 IRS, AND 9.75 IRS AXLES
08-18-2
MIL ON - P0506 AND/OR P0505 - HESITATION/LOSS OF RPM/DIFFICULTY STARTING/LOW IDLE RPM
08-11-6
A/C COMPRESSOR THUMP NOISE
08-10-4
CHROME GRILLE - PEELING, BLISTERING OR WRINKLING
08-9-5
4.0L/4.6L - HARD START/ROUGH RUNNING - AFTER LONG HOT SOAK / DIP IN RPM WHEN COMING TO A STOP - BUILT ON OR BEFORE 4/2/2008
08-7-6
SPARK PLUG REMOVAL INSTRUCTIONS - 4.6L 3V/5.4L 3V/6.8L 3V
08-5-9
THUMPING/LOUD FLUTTER - BEHIND DASH IN DEFROST MODE - LACK OF AIRFLOW TO FLOOR - MANUAL A/C ONLY
08-1-3
4.0L - PCM BRACKET BUZZ/HUM NOISE FROM CENTER/RIGHT SIDE DASH AREA
07-25-10
LOOSE OUTSIDE SEAT CUSHION SHIELD - VEHICLES BUILT BEFORE 7/1/2007
07-25-2
TAILGATE STRIKER - NOISE/RATTLE
07-24-6
REAR BRAKE RATTLE OVER BUMPS
07-17-4
PARKING BRAKE RELEASE HANDLE BREAKS - VEHICLES BUILT BEFORE 12/1/2006
07-12-9
INTERMITTENT CONDITION - SHIFTER REQUIRES MANUAL OVERRIDE TO GET VEHICLE OUT OF PARK - VEHICLES BUILT ON OR BEFORE 11/14/2006
07-12-6
FRONT BLOWER MOTOR WHISTLE NOISE - VEHICLES BUILT ON OR BEFORE 06/7/2007
07-12-3
RCM FAULT REPORTING USING DTCS AND BIT-MAPPED PARAMETER IDENTIFIERS (PIDS) - SERVICE TIPS
07-12-2
16 INCH BRIGHT MACHINED WHEEL - CORROSION AND ETCHING
07-10-12
VARIOUS DRIVEABILITY AND A/C PERFORMANCE QUALITY SYMPTOMS - 4.6L 3V 6R60 EQUIPPED VEHICLES ONLY
07-7-3
FRONT SEAT MANUAL LUMBAR INOPERATIVE
07-6-3
6R60/75 - DTC-MECHATRONIC ASSEMBLY / POSSIBLE WRENCH LIGHT ON
07-5-13
DISCHARGED BATTERIES - VEHICLES IN STORAGE/LIMITED USAGE
07-5-8
BATTERY SERVICE - OPERATION OF BATTERY EYE - CHARGING SERVICE TIPS
07-4-3
LEATHER-WRAPPED STEERING WHEEL - LEATHER COMING LOOSE
06-25-15
ALUMINUM BODY PANELS - CORROSION - SERVICE TIP
06-25-3
PIONEER NAVIGATION RADIO - SEEK FUNCTION INOPERATIVE - SERVICE TIP
06-24-14
LOWER STEERING COLUMN SHAFT POP / CLUNK NOISE
06-21-19
HEATER CORE LEAKAGE AND ELECTROLYSIS (INFORMATION ONLY)
06-21-16
WATER NOISE - WATER ACCUMULATION INSIDE DOORS
06-21-7
AUDIO / NAVIGATION SERVICE AND ORDERING PROCEDURES
06-19-14
NO CRANK / STARTER TERMINAL FATIGUE
06-19-12
DTC P0340/P0344/P0345/P0349 - 4.6L 3V AND 5.4L 3V
06-18-15
IGNITION DIAGNOSTICS
06-17-13
CALIBRATION UPDATE 4.0L - VARIOUS SYMPTOMS - SURGE, HESITATION, TORQUE CONVERTER CYCLING, NO UP SHIFT AFTER A FORCED DOWNSHIFT, AND POOR A/C PERFORMANCE
06-17-5
WHEEL LIP MOULDINGS - POOR FIT TO BUMPER FASCIA
06-14-8
WIND / WHISTLE NOISE AT 40-70 MPH (64-113 KM/H) - LEFT MIRROR AREA
06-12-12
A/C COMPRESSOR THUMP NOISE WITH 4.0L V-6
06-11-5
GAP OR WARPAGE AT TOP OF TAILGATE LINER
06-10-7
NO START WITH INSTRUMENT CLUSTER INOPERATIVE
06-7-10
MIL ON WITH DTC P2004 THROUGH P2008, P151A, P2015, P2020 - 4.6L 3V
06-7-1
NEUTRAL TOW CAPABILITY - SERVICE KIT REQUIREMENTS
06-6-9
ANTI-LOCK BRAKE SYSTEM / TRACTION CONTROL / ROLL STABILITY CONTROL INDICATOR (ABS / TC / RSC) WARNING LAMP ON WITH DTC C1440
________________
TSBs found:54
gary s
Well-Known Member
geeeeez,
can that list get any longer
my 07 4.6 issues:
tranny bump, crappy cheap plastic "chrome" overlays(popping/cracking noise), premature fogs burning out.
other then that evryhing else was ok after 2 years
can that list get any longer
my 07 4.6 issues:
tranny bump, crappy cheap plastic "chrome" overlays(popping/cracking noise), premature fogs burning out.
other then that evryhing else was ok after 2 years
Last edited by a moderator:
Oldtimer
Active Member
Oldtimer
Active Member
Issues are downshift to low bump and drivers side air bag warning light coming on.
Jim
Jim
